Beware of abnormal noise caused by flake ice machine failure

Beware of abnormal noise caused by flake ice machine failure

https://www.sicecold.com/blog-Tech-knowledge-10706/

Normal noise within 2 meters of flake ice machine: small supermarket ice machine, 40-60 minutes, general, ordinary indoor conversation, large and medium-sized industrial flake ice machine, 60-70 minutes, a bit noisy. If the noise of flake ice machine exceeds this range, it may be caused by abnormal noise of flake ice machine failure.

There are many reasons for abnormal noise inside the evaporator of flake ice machine. The evaporator is an important ice-making component of flake ice machine. When abnormal noise occurs, it may affect the output of equipment and ice flake effect. The following reasons may cause flake ice machine noise:

1. Flake ice machine ice blade offset

We all know that the distance between the ice blade of flake ice machine and the ice bucket of evaporator is about 15 wires (0.15 mm), and the gap is very close. If the ice blade is slightly misaligned, uneven ice cutting or ice blade is stuck, abnormal noise inside the ice bucket will occur.

Solution: Contact the after-sales service of flake ice machine manufacturer to adjust the ice blade. (Must be repaired by professionals)

2. The flake ice machine brine concentration is too low or too high

The flake ice machine needs to add salt during operation. If the brine ratio is not appropriate, the ice bucket of the flake ice machine will have a higher ice hardness. At this time, the ice knife will not be easy to cut off the ice on the inner wall of the ice bucket, or it will not be cut cleanly, which will cause abnormal noise.

Solution: Please add salt according to the instructions in the manual. The method of adding salt to the flake ice machine.

3. The flake ice machine brine pipeline is blocked, or there is air, or the brine pump is damaged.

Solution: Check the ice cleaning pipeline to ensure that the brine replenishment is normal. There is air in the brine pipe in the flake ice machine. Expel the air in the pipe to ensure that the water tank supplies brine normally.

The flake ice machine brine pump is damaged. Solution: Replace the brine pump

                                 SICECOLD industrial flake ice machine

                                                      Daily output: From 1ton to 40tons

Beware of abnormal noise caused by flake ice machine failure

Beware of abnormal noise caused by flake ice machine failure